How to remove the Rack and Pinion steering gear assembly on a Honda Pilot?

Honda vehicles and 2006 or earlier Acura models have the same steps to follow when removing and installing their Rack And Pinion. Start by unplugging the cable from the negative end of the battery and get all the power steering fluid out of the remote reservoir using a vacuum tool or taking off the fluid line. Uncover the steering shaft inside your car, and if it has one, place a note showing how the shafts relate at the U-joint. Later, extract the lower pinch bolt. After unlatching the front wheel lug nuts and lifting the car, place jack stands securely under it before you take off both front wheels. Pull off both the pressure line from the pump and its engine-attachment bracket. Place a device to hold the engine, take off the tie-rod ends from the steering knuckles, and unfasten the mounting bolts that keep the sub frame stiffener plate in place. Take off the exhaust hanger before the under-floor catalytic converter, then disconnect the converter from the pipes that connect to the muffler. Pull the power steering pressure switch's electrical connector, remove the driveshaft center support bearing and safety loops, and engine splash shield. Keep the sub frame in place with floor jacks, untighten, but don't remove, the four screws that connect it to the truck's frame. Disconnect the mounting bolts that secure the sub frame to the front and rear, then carefully lower your floor jacks until the tightly-held bolts reach them. Put caught sonics on sub frame's return line, place a tray under car, and free steering gear's pressure and flow lines with a flare tool. Take off the steering gear stiffener bracket from the sub frame. Then loosen the four main sub frame mounting bolts and lower the floor jacks again. Lift the steering gear from the left tire well while prying out its clamp bolts and securing it with a steering gear assembly. Put the steering gear back where it started, with tight bolts for the gear mounting and stiffener bracket, line up the sub frame precisely using reference marks, hook up the battery cables in their correct order, refill the power steering pump with its needed fluid, drain the lines, let air out of the system, and check for any fluid leaks. End with a test drive, then have the front part of your car aligned properly to make sure everything works well.

Genuine Honda Pilot Rack And Pinion

Steering Rack And Pinion

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

26 Rack And Pinions found

View related parts
Honda Pilot Steering Gear Box
Part Number: 53601-TG7-A02
$1153.63 MSRP: $1716.72
You Save: $563.09 (33%)
ADD TO CART
Product Specifications
- Other Name: Steering Gear; Gear Assembly
- Replaces: 53601-TG7-A01
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2016-2022 Honda Pilot | 5 Door Black (AWD), 5 Door Black Edition AWD, 5 Door ELITE (AWD), 5 Door Elite AWD, 5 Door EX (2WD), 5 Door EX (AWD), 5 Door EX-L (2WD), 5 Door EX-L (AWD), 5 Door EX-L 2WD, 5 Door EX-L AWD, 5 Door LX (2WD), 5 Door LX (AWD), 5 Door SE (2WD), 5 Door SE (AWD), 5 Door SE 2WD, 5 Door SE AWD, 5 Door Sport 2WD, 5 Door Sport AWD, 5 Door Touring (2WD), 5 Door Touring (AWD), 5 Door Touring 2WD, 5 Door Touring 7-Passenger 2WD, 5 Door Touring 7-Passenger AWD, 5 Door Touring AWD, 5 Door TrailSport AWD | 9AT, KA 6AT, KA 9AT
View related parts
Honda Pilot Box, Power Steering Gear
Part Number: 53601-SZA-A51
$1329.87 MSRP: $1919.00
You Save: $589.13 (31%)
ADD TO CART
Product Specifications
- Other Name: Steering Gear; Gear Assembly
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2012-2015 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX 4.4 (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX 4.2 (4WD), 5 Door SE (2WD), 5 Door SE (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 53601-S9V-A02
$1343.92 MSRP: $1939.28
You Save: $595.36 (31%)
ADD TO CART
Product Specifications
- Other Name: Steering Gear; Gear Assembly
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2005-2008 Honda Pilot | 5 Door EX, 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L, 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door EX-SE (2WD), 5 Door EX-SE (4WD), 5 Door LX, 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX-VP (2WD), 5 Door LX-VP (4WD) | KA 5AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 53601-SZA-A11
$1329.87 MSRP: $1919.00
You Save: $589.13 (31%)
ADD TO CART
Product Specifications
- Other Name: Steering Gear; Gear Assembly
- Replaces: 53601-SZA-A02, 53601-SZA-A01
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2009-2011 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Rack, Reman
Part Number: 06536-SZA-505RM
$651.17 MSRP: $933.58
You Save: $282.41 (31%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly
- Replaces: 53600-SZA-A11RM, 53600-SZA-A02RM
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2009-2011 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Steering Rack
Part Number: 53626-SZA-A01
$102.21 MSRP: $144.37
You Save: $42.16 (30%)
ADD TO CART
Product Specifications
- Other Name: Rack
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2009-2011 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Steering Rack
Part Number: 53626-SZA-A51
$101.79 MSRP: $143.77
You Save: $41.98 (30%)
ADD TO CART
Product Specifications
- Other Name: Rack
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2012-2015 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX 4.4 (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX 4.2 (4WD), 5 Door SE (2WD), 5 Door SE (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T90-A24
$2302.55 MSRP: $3322.58
You Save: $1020.03 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Replaces: 53620-T90-A23, 53620-T90-A21, 53620-T90-A22
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2025 Honda Pilot | 5 Door Black Edition AWD, 5 Door Elite AWD, 5 Door Touring AWD | 10AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T90-A23
$2302.55 MSRP: $3322.58
You Save: $1020.03 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Replaced by: 53620-T90-A24
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2023-2024 Honda Pilot | 5 Door Elite AWD, 5 Door Touring AWD | 10AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T90-A04
$2306.89 MSRP: $3328.85
You Save: $1021.96 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2025 Honda Pilot | 5 Door EX-L AWD | 10AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T90-A03
$2306.89 MSRP: $3328.85
You Save: $1021.96 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Replaces: 53620-T90-A01, 53620-T90-A02
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2023-2024 Honda Pilot | 5 Door EX-L 7-Passenger AWD, 5 Door EX-L AWD, 5 Door LX AWD | 10AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 53620-T91-A24
$2369.22 MSRP: $3418.78
You Save: $1049.56 (31%)
ADD TO CART
Product Specifications
- Other Name: RACK, POWER STEERING; Gear Assembly, Short Rack
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2025 Honda Pilot | 5 Door Sport 2WD | 10AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T91-A23
$2369.22 MSRP: $3418.78
You Save: $1049.56 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Replaces: 53620-T91-A22, 53620-T91-A21
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2023-2024 Honda Pilot | 5 Door Sport 2WD | 10AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 53620-T91-A14
$2369.22 MSRP: $3418.78
You Save: $1049.56 (31%)
ADD TO CART
Product Specifications
- Other Name: RACK, POWER STEERING; Gear Assembly, Short Rack
- Replaces: 53620-T91-A12, 53620-T91-A11, 53620-T91-A13
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2025 Honda Pilot | 5 Door Touring 2WD | 10AT
View related parts
Honda Pilot Steering Gear Box Assembly
Part Number: 53620-T91-A13
$2369.22 MSRP: $3418.78
You Save: $1049.56 (31%)
ADD TO CART
Product Specifications
- Other Name: G/BOX ASSY-, STRG; Gear Assembly, Short Rack
- Replaced by: 53620-T91-A14
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2023-2024 Honda Pilot | 5 Door Touring 2WD | 10AT
View related parts
Honda Pilot Ps Rack, Reman
Part Number: 06536-SZA-306RM
Product Specifications
- Other Name: Gear Assembly
- Replaces: 53600-SZA-A51RM
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2012-2015 Honda Pilot | 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX 4.4 (4WD), 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX 4.2 (4WD), 5 Door SE (2WD), 5 Door SE (4WD), 5 Door Touring (2WD), 5 Door Touring (4WD) | KA 5AT
View related parts
Honda Pilot Power Steering Rack (Remanufactured)
Part Number: 06536-S9V-506RM
Product Specifications
- Other Name: Steering Gear; Gear Assembly
- Replaces: 53600-S9V-A01RM
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2003-2004 Honda Pilot | 5 Door EX, 5 Door EX-L, 5 Door LX | KA 5AT, KL 5AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 06536-S9V-505RM
Product Specifications
- Other Name: Steering Gear
- Replaces: 53600-S9V-A02RM
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2005-2008 Honda Pilot | 5 Door EX, 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L, 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door EX-SE (2WD), 5 Door EX-SE (4WD), 5 Door LX, 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX-VP (2WD), 5 Door LX-VP (4WD) | KA 5AT
View related parts
Honda Pilot Power Steering Rack
Part Number: 53601-S9V-A01
Product Specifications
- Other Name: Rack, Power Steering
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2003-2004 Honda Pilot | 5 Door EX, 5 Door EX-L, 5 Door LX | KA 5AT, KL 5AT
View related parts
Honda Pilot Steering Rack
Part Number: 53626-S3V-A01
Product Specifications
- Other Name: Rack
- Warranty: This genuine part is guaranteed by Honda's factory warranty.
Fits the following Vehicles:
- 2003-2008 Honda Pilot | 5 Door EX, 5 Door EX (2WD), 5 Door EX (4WD), 5 Door EX-L, 5 Door EX-L (2WD), 5 Door EX-L (4WD), 5 Door EX-SE (2WD), 5 Door EX-SE (4WD), 5 Door LX, 5 Door LX (2WD), 5 Door LX (4WD), 5 Door LX-VP (2WD), 5 Door LX-VP (4WD) | KA 5AT, KL 5AT

| Page 1 of 2 |Next >

1-20 of 26 Results

Honda Pilot Rack And Pinion

The Rack And Pinion in Honda Pilot is an essential component that transform the rotational force exerted at the steering wheel into the linear force required to move the front wheels from side to side. Rack And Pinion is a part of the control system of the wheels' position, in which a pinion gear is fastened to the steering column and a toothed bar called the rack that is enclosed in a metal tube and directs the wheels when a person turns the steering wheel. Almost all new Honda Pilot cars utilize a power-assisted Rack And Pinion as it employs the use of hydraulic pressure to make it easier to steer. This system consists of a cylinder that contains fluid coupled with a piston that delivers help regarding the rotational force of the steering wheel. In earlier models the racks were hand operated but in the current models, some forms of hydraulic help is incorporated to improve its operation. There are possible problems that deal with the Honda Pilot Rack And Pinion that stem from normal use and the like that may cause leaks or stiff steering. It is always recommended to repair the Rack And Pinion on a regular basis so that they can last long and also perform their required operations without any complications since some issues can arise and compromise the handling of the vehicle as well as safety of the road.

In search of affordable OEM Honda Pilot Rack And Pinion? Consider browsing through our extensive inventory of genuine Honda Pilot Rack And Pinion. Not only do we provide market-leading prices and a manufacturer's warranty, but we also pride ourselves on exceptional customer service and swift delivery.

Honda Pilot Rack And Pinion Parts Questions & Experts Answers

Power Steering Rack
53601-S9V-A02
Q: How to remove the Rack and Pinion steering gear assembly on a Honda Pilot?
A:
Honda vehicles and 2006 or earlier Acura models have the same steps to follow when removing and installing their Rack And Pinion. Start by unplugging the cable from the negative end of the battery and get all the power steering fluid out of the remote reservoir using a vacuum tool or taking off the fluid line. Uncover the steering shaft inside your car, and if it has one, place a note showing how the shafts relate at the U-joint. Later, extract the lower pinch bolt. After unlatching the front wheel lug nuts and lifting the car, place jack stands securely under it before you take off both front wheels. Pull off both the pressure line from the pump and its engine-attachment bracket. Place a device to hold the engine, take off the tie-rod ends from the Steering Knuckles, and unfasten the mounting bolts that keep the sub frame stiffener plate in place. Take off the exhaust hanger before the under-floor catalytic converter, then disconnect the converter from the pipes that connect to the muffler. Pull the power steering pressure switch's electrical connector, remove the driveshaft center support bearing and safety loops, and engine splash shield. Keep the sub frame in place with floor jacks, untighten, but don't remove, the four screws that connect it to the truck's frame. Disconnect the mounting bolts that secure the sub frame to the front and rear, then carefully lower your floor jacks until the tightly-held bolts reach them. Put caught sonics on sub frame's return line, place a tray under car, and free steering gear's pressure and flow lines with a flare tool. Take off the steering gear stiffener bracket from the sub frame. Then loosen the four main sub frame mounting bolts and lower the floor jacks again. Lift the steering gear from the left tire well while prying out its clamp bolts and securing it with a steering gear assembly. Put the steering gear back where it started, with tight bolts for the gear mounting and stiffener bracket, line up the sub frame precisely using reference marks, hook up the battery cables in their correct order, refill the power steering pump with its needed fluid, drain the lines, let air out of the system, and check for any fluid leaks. End with a test drive, then have the front part of your car aligned properly to make sure everything works well.